Viking Range F20636D User Manual

Viking Use & Care Manual

Viking Range Corporation

111 Front Street

Greenwood, Mississippi 38930 USA

(662) 455-1200

For product information,

call 1-888-VIKING1 (845-4641)

or visit the Viking Web site at

vikingrange.com

5 Series

Professional Custom Built-In

Gas Rangetops

F20636D EN

(122112)

Warnings

Warning and Important Safety Instructions appearing in this manual

are not meant to cover all possible conditions and situations that may

occur. Common sense, caution, and care must be exercised when

installing, maintaining, or operating the appliance.

WARNING

If the information in this manual is not followed exactly, a

fire or explosion may result causing property damage,

personal injury or death.

ALWAYS contact the manufacturer about problems or conditions you do not

understand.

WHAT TO DO IF YOU SMELL GAS:

• DO NOT try to light any appliance.

• DO NOT touch any electrical switch.

Recognize Safety Symbols, Words, Labels

• DO NOT use any phone in your building.

• Immediately call your gas supplier from a neighbor's phone. Follow

the gas supplier's instructions.

DANGER

Hazards or unsafe practices which WILL result in

severe personal injury or death

• If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer,

service agency or the gas supplier.

WARNING

Hazards or unsafe practices which COULD result in

death or severe personal injury

WARNING

To avoid risk of property damage, personal injury or death;

follow information in this manual exactly to prevent a fire or

explosion. DO NOT store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any appliance.

CAUTION

Hazards or unsafe practices which COULD result in

minor personal injury.

All safety messages will identify the hazard, tell you how

to reduce the chance of injury, and tell you what can happen if

the instructions are not followed.

Read and follow all instructions before using this appliance to prevent

the potential risk of fire, electric shock, personal injury or damage to the

appliance as a result of improper usage of the appliance. Use appliance

only for its intended purpose as described in this manual.

To ensure proper and safe operation: Appliance must be properly

installed and grounded by a qualified technician. DO NOT attempt to

adjust, repair, service, or replace any part of your appliance unless it is

specifically recommended in this manual. All other servicing should be

referred to a qualified servicer. Have the installer show you the location of

the gas shutoff valve and how to shut it off in an emergency. A certified

technician is required for any adjustments or conversions to Natural or LP gas.

KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE.

Warnings

To Prevent Fire or Smoke Damage

• Be sure all packing materials are removed from the appliance before

operating it.

• Keep area around appliance clear and free from combustible materials,

gasoline, and other flammable vapors and materials.

• If appliance is installed near a window, proper precautions should be taken

to prevent curtains from blowing over burners.

Child Safety (cont.)

• Children must be taught that the appliance and utensils in it can be hot.

Let hot utensils cool in a safe place, out of reach of small children.

Children should be taught that an appliance is not a toy. Children should not

be allowed to play with controls or other parts of the appliance.

Cooking Safety

•

NEVER leave any items on the rangetop. The hot air from the vent may ignite

flammable items and may increase pressure in closed containers which may

cause them to burst.

• To eliminate the hazard of reaching over hot surface burners, cabinet

storage should not be provided directly above a unit. If storage is provided,

it should be limited to items which are used infrequently and which are

safely stored in an area subjected to heat from an appliance. Temperatures

may be unsafe for some items, such as volatile liquids, cleaners or

aerosol sprays.

• Many aerosol-type spray cans are EXPLOSIVE when exposed to heat and

may be highly flammable. Avoid their use or storage near an appliance.

• Many plastics are vulnerable to heat. Keep plastics away from parts of the

appliance that may become warm or hot. DO NOT leave plastic items on

the rangetop as they may melt or soften if left too close to the vent or a

lighted surface burner.

•

ALWAYS place a pan on a surface burner before turning it on. Be sure

you know which knob controls which surface burner. Make sure the correct

burner is turned on and that the burner has ignited. When cooking is

completed, turn burner off before removing pan to prevent exposure to

burner flame.

• Combustible items (paper, plastic, etc.) may ignite and metallic items

may become hot and cause burns. DO NOT pour spirits over hot foods.

•

ALWAYS adjust surface burner flame so that it does not extend beyond the

bottom edge of the pan. An excessive flame is hazardous, wastes energy

and may damage the appliance, pan or cabinets above the appliance.

This is based on safety considerations.

In Case of Fire

Turn off appliance and ventilating hood to avoid spreading the flame. Extinguish

flame then turn on hood to remove smoke and odor.

• Smother fire or flame in a pan with a lid or cookie sheet. DO NOT use water

on grease fires. Use baking soda, a multipurpose dry chemical or foam-type

extinguisher to smother fire or flame Let fat cool before attempting to

handle it. DO NOT allow grease to collect in vents. Wipe up spillovers

immediately.

• NEVER leave a cooking operation unattended especially when using a high

heat setting or when deep fat frying. Boil overs cause smoking and greasy

spillovers may ignite. clean up greasy spills as soon as possible.

DO NOT use high heat for extended cooking operations.

• DO NOT heat unopened food containers, build up of pressure may cause

the container to explode and result in injury.

• NEVER pick up or move a flaming pan.

• GREASE–Grease is flammable and should be handled carefully. DO NOT

use water on grease fires. Flaming grease can be extinguished with

baking soda or, if available, a multipurpose dry chemical or foam type

extinguisher. Let fat cool before attempting to handle it. Wipe up

spillovers immediately.

• Use dry, sturdy pot-holders. Damp pot-holders may cause burns from steam.

Dishtowels or other substitutes should NEVER be used as potholders

because they can trail across hot surface burners and ignite or get caught on

appliance parts.

•

ALWAYS let quantities of hot fat used for deep fat frying cool before

attempting to move or handle.

Child Safety

• DO NOT let cooking grease or other flammable materials accumulate in or

near the appliance, hood or vent fan. Clean hood frequently to prevent

grease from accumulating on hood or filter. When flaming foods under the

hood, turn the fan off.

• NEVER wear garments made of flammable material or loose fitting or

long-sleeved apparel while cooking. Clothing may ignite or catch utensil

handles.

• NEVER leave children alone or unsupervised near the appliance when it is in

use or is still hot.

• NEVER allow children to sit or stand on any part of the appliance as they

could be injured or burned.

• DO NOT store items of interest to children over the unit. Children climbing to

reach items could be seriously injured.

• PREPARED FOOD WARNING: Follow food manufacturer's instructions. If a

plastic frozen food container and/or its cover distorts, warps, or is otherwise

Warnings

Cooking Safety (cont.)

Heating Elements

• Burners may be hot even though they are dark in color. Areas near burners

may become hot enough to cause burns.

damaged during cooking, immediately discard the food and its container. The

food could be contaminated

• If you are “flaming” liquor or other spirits under an exhaust, TURN THE

FAN OFF. The draft could cause the flames to spread out of control.

• Once the unit has been installed as outlined in the Installation

Instructions, it is important that the fresh air supply is not obstructed.

The use of a gas cooking appliance results in the production of heat and

moisture in the room in which it is installed. Ensure that the kitchen is

well-ventilated. Keep natural venting holes open or install a mechanical

ventilation device. Prolonged or intensive use of the appliance may call

for additional (such as opening a window) or more effective ventilation

(such as increasing the level of a mechanical ventilation if present).

•

During and after use, DO NOT touch or let clothing or other flammable

materials contact heating elements, or areas near elements, until they have

had sufficient time to cool.

Cleaning Safety

• Turn off all controls and wait for appliance parts to cool before touching or

cleaning them. DO NOT touch the burner grates or surrounding areas until

they have had sufficient time to cool.

• Clean appliance with caution. Use care to avoid steam burns if a wet sponge

or cloth is used to wipe spills on a hot surface. Some cleaners can produce

noxious fumes if applied to a hot surface.

Cookware Safety

• Use pans with flat bottoms and handles that are easily grasped and stay

cool. Avoid using unstable, warped, easily tipped or loose-handled pans.

Also avoid using pans, especially small pans, with heavy handles as they

could be unstable and easily tip. Pans that are heavy to move when filled

with food may also be hazardous.

Important notice regarding pet birds:

NEVER keep pet birds in the kitchen or in rooms where the fumes from the

kitchen could reach. Birds have a very sensitive respiratory system. Fumes

released due to overheated cooking oil, fat, margarine and overheated non-

stick cookware may be may be harmful or fatal to birds.

• Be sure utensil is large enough to properly contain food and avoid boil

overs. Pan size is particularly important in deep fat frying. Be sure pan will

accommodate the volume of food that is to be added as well as the bubble

action of fat.

• To minimize burns, ignition of flammable materials and spillage due to

unintentional contact with the utensil, DO NOT extend handles over

adjacent surface burners. ALWAYS turn pan handles toward the side or back

of the appliance, not out into the room where they are easily hit or reached

by small children.

• NEVER let a pan boil dry as this could damage the utensil and the appliance.

• Only certain types of glass, glass/ceramic, ceramic or glazed utensils are

suitable for rangetop surface usage without breaking due to the sudden

change in temperature. Follow manufacturer's instructions when using glass.

• This appliance has been tested for safe performance using conventional

cookware. DO NOT use any devices or accessories that are not specifically

recommended in this guide. DO NOT use eyelid covers for the surface units,

stovetop grills, or add-on oven convection systems. The use of devices or

accessories that are not expressly recommended in this manual can create

serious safety hazards, result in performance problems, and reduce the life

of the components of the appliance.

• The flame of the burner should be adjusted to just cover the bottom of

the pan or pot. Excessive burner setting may cause scorching of

adjacent countertop surfaces, as well as the outside of the utensil. This

is based on safety considerations.

Warnings

Before Using Rangetop

All products are wiped clean with solvents at the factory to remove

any visible signs of dirt, oil, and grease which may have remained from

the manufacturing process. Before cooking, clean the rangetop

thoroughly with a hot, soapy damp cloth. There may be some burn off

and odors on first use of the appliance—this is normal.

WARNING

NEVER use appliance as a space heater to heat or warm a room to prevent

potential hazard to the user and damage to the appliance. Also, DO NOT

use the rangetop as a storage area for food or cooking utensils.

All professional models include:

• Exclusive VSH™ Pro Sealed Burner System (Vari Simmer™ to High)—

combination of patented burner and top design provide cleanability

plus superior performance at simmer and high.

Power Failure

• Exclusive one-piece tooled and porcelainized cooking surface

contains spills for easy cleaning.

• Removable knobs, grates, and burner ports/caps for easy cleaning.

WARNING

POWER FAILURE WARNING

Due to safety considerations and the possibility of personal injury in

attempting to light and extinguish the burner, the grill should, not under

any circumstances, be used during a power failure. The grill burner

control should always remain in the “OFF” position during a power failure.

All designer models include:

• Brass sealed burners with porcelain/cast-iron caps and automatic

ignition/re-ignition

• One-piece, extremely durable steel top

• Separate spill collection areas; each area holds up to 1-1⁄2 quarts of

liquid spillover

• Grate design provides continuous surface for easy movement of pots

• Durable knobs with childproof, push-to-turn safety feature

If power failure occurs, the electric igniters will not work. No attempt

should be made to operate the appliance during a power failure. Make

sure the burner control is in the “OFF” position.

Momentary power failure can occur unnoticed. The rangetop is affected

only when the power is interrupted. When it comes back on, the rangetop

will function properly without any adjustments. A “brown-out” may or may

not affect rangetop operation, depending on how severe the power loss is.

Cooking Vessels

Each cook has his or her own preference for the particular cooking

vessels that are most appropriate for the type of cooking being done.

Any and all cooking vessels are suitable for use in the range and it is

not necessary to replace your present domestic vessels with commercial

cookware. This is a matter of personal choice. As with any cookware,

yours should be in good condition and free from excessive dents on the

bottom to provide maximum performance and convenience.

WARNING

BURN OR ELECTRICAL SHOCK HAZARD

Make sure all controls are “OFF” before cleaning. Failure to

do so can result in burns or electrical shock.

Note: When using big pots and/or high flames, it is recommended to use

the front burners. There is more room in the front and potential cleanup at

rear of appliance due to staining or discoloration will be minimized.

CAUTION

DO NOT store items of interest to children over the unit. Children

climbing to reach items could be seriously injured.

Rangetop Features (Professional)

Left Rear Burner

Control Knob

(15,000 BTU)

Left Front Burner

Control Knob

(15,000 BTU)

Char-Grill

Control

Knob

Griddle

Control

Knob

Right Rear Burner

Control Knob

(15,000 BTU)

Right Front Burner

Control Knob

Griddle

Indicator Light

(15,000 BTU)

GRIDDLE

Denotes models

which have a

TruPower Plus™

18,500 BTU Burner

30” Four-Burner

36” Six-Burner

36” Four-Burner/Griddle

48” Six-Burner/Griddle

36” Four-Burner/Char-Grill

48” Six-Burner/Char-Grill

48” Eight Burner

48” Four-Burner/Char-Grill/Griddle model shown

1. Four 15,000 BTU sealed burners with porcelain/

Cast-iron caps and automatic ignition/Re-ignition

2. Stainless steel island trim

48” Four-Burner/Char-Grill/Griddle 48” Four-Burner/24” Griddle

3. Char-Grill (Optional)

4. Griddle (Optional)

5. Identification plate

Operation

Lighting Burners

Surface Cooking Tips

All burners are ignited by electric ignition. There are no

open-flame, “standing” pilots.

• Use low or medium flame heights when cooking in vessels that are

poor conductors of heat, such as glass, ceramic, and cast-iron.

Reduce the flame height until it covers approximately 1/3 of the

cooking vessel diameter. This will ensure more even heating within

the cooking vessel and reduce the likelihood of burning or scorching

the food.

Surface Burners/Automatic Re-Ignition

To light the surface burners, push and turn the appropriate

control knob counter clockwise to any position. This control is

both a gas valve and an electric switch. Burners will ignite at any

“ON” position with the automatic re-ignition system. If the flame

goes out for any reason, the burners will automatically re-ignite if the gas

is still flowing. When gas is permitted to flow to the burners, the electric

igniters start sparking. On all surface igniters you should hear a “clicking”

sound. If you do not, turn off the control and check that the unit is

plugged in and that the fuse or circuit breaker is not blown or tripped.

• Reduce the flame if it is extending beyond the bottom of the

cooking vessel. A flame that extends along the sides of the vessel is

potentially dangerous, heats the utensil handle and kitchen instead

of the food, and wastes energy.

• Reduce the flame height to the minimum level necessary to perform

the desired cooking process. Remember that food cooks just as

quickly at a gentle boil as it does at a rolling boil. Maintaining a

higher boil than is necessary wastes energy, cooks away moisture,

and causes a loss in food flavor and nutrient level.

Within a few moments, enough gas will have traveled to the burner to

light. When the burner lights, turn the burner control to any position to

adjust the flame size. Setting the proper flame height for the desired

cooking process and selecting the correct cooking vessel will result in

superior cooking performance, while also saving time and energy.

• The minimum pot or pan (vessel) diameter recommended is

6” (15 cm). Use of pots or pans as small as 4” (10 cm) is possible

but not recommended.

Surface Heat Settings*

VariSimmer™

Heat Setting

Use

Simmering is a cooking technique in which foods are cooked in hot

liquids kept at or just barely below the boiling point of water. Simmering

ensures gentle treatment than boiling to prevent food from toughening

and/or breaking up. The size of the pan and the volume of food can have

a significant effect on how high or low a flame is needed for simmering.

For this reason, Viking range and rangetop burners are engineered with a

VariSimmer setting. The VariSimmer setting is not just one simmer setting,

but provides a variable range of simmer settings. This variable range of

simmer settings allows you to adjust the flame height to achieve the best

simmer depending on the type and quantity of food being simmered. It

is this ability that makes the VariSimmer setting the most accurate and

trustworthy simmer on the market.

Melting small quantities

Steaming rice

Simmering sauces

Simmer

Melting large quantities

Low

Low-temperature frying (eggs, etc.)

Simmering large quantities

Heating milk, cream sauces, gravies,

and puddings

Med Low

Sauteing and browning, braising, and

pan-frying

Maintaining slow boil on large quantities

Med

High-temperature frying

Pan broiling

Maintaining fast boil on large quantities

Med High

High

TruPower Plus™ Burner (where applicable)

Certain model ranges are equipped with a TruPower Plus 18,500 BTU

burner in the front right burner position. This burner is designed to

provide extra-high heat output, especially when using large pans, and

should be used for boiling large quantities or if you need to bring

something to a boil quickly. While the TruPower Plus burner has the extra

power needed to bring large quantities of liquid to a boil rapidly, it is also

able to be turned down low enough to provide a very low and delicate

simmer making this burner the most versatile on the market.

Boiling water quickly

Deep-fat frying in large utensil

*Note: The above information is given as a guide only. You may need

to vary the heat settings to suit your personal requirements.

Operation

Griddle/Simmer Plate (on applicable models)

Griddle/Simmer Plate Clean Up & Care

The optional 15,000 BTU griddle is constructed of stainless steel and is

uniquely designed to offer excellent cooking performance as well as

easy cleanup. The griddle is equipped with an electronic thermostat to

maintain an even temperature across the griddle once the desired

temperature has been set. The griddle has a power “ON” indicator light

which glows when the griddle thermostat has been turned on. This will

cycle on and off as needed to indicate the thermostat is maintaining the

selected temperature. Before the griddle is used it is important to

season the griddle. This seasoning process will change the appearance

of the griddle plate. However, it will also prevent food from sticking and

protect the surface from moisture.

• It is not necessary to wash the griddle after every use. When light

cooking is performed and AFTER the griddle has cooled, simply

wipe down the surface with a clean cloth or paper towel. The oils in

the food which cooked on the griddle surface will naturally season

the griddle providing a “natural” non-stick surface.

• After heavy cooking is completed and the griddle is still warm

enough to create steam, pour a small amount of club soda at room

temperature directly on the griddle. Using a metal spatula, pull oils

and food particles toward the trough in front. Wipe entire surface with

a paper towel. Follow with the seasoning process of applying oil.

• Keeping the griddle well-seasoned will prevent the griddle from

developing surface rust. If the griddle is not used for a period of

time, it must be re-seasoned. The griddle must be re-seasoned each

time after it is washed.

Seasoning the Griddle Before the First Use

• Scrub the griddle plate with a mixture of one quart warm water and

1/4 cup white vinegar, using a blue Scotch-Brite™ pad. Dry thoroughly.

• Wash griddle with warm, soapy water. Rinse off and dry thoroughly.

• Season griddle by thinly coating the surface with approximately 1⁄2 to

1 teaspoon unsalted vegetable oil. Apply to entire griddle using a

paper towel or clean cloth. Let oil sit on griddle for approximately 1

hour and then wipe with a clean cloth or paper towel to absorb any

residual oil. The griddle is now ready to be used.

• Non-stick cooking spray is not recommended as it contains a high

water content that has a tendency to burn quickly.

• Corn oil is not recommended as it has a high sugar level. It will

caramelize and burn on the surface making it very difficult to remove.

• After using the griddle, always remove the grease trough located in

the front. Simply pull the trough towards you and lift out. The trough

or tray trap needs to be cleaned after each use. A fire hazard may

occur if grease is accumulated in the trough.

Griddle/Simmer Plate Operation

Note: It is normal for the griddle to darken over time. This is the sign

of a well-seasoned griddle.

• Turn the griddle control knob counterclockwise to the desired

temperature setting. The power “ON” indicator light will glow

indicating the griddle thermostat is on.

• IMPORTANT: NEVER flood a hot griddle with cold water. This

thermal shock promotes griddle warping and can cause the griddle

to crack if continued over a period of time.

• For heavy duty cleaning, Viking offers a Griddle Cleaning Kit (model

#GCK). This fast and effective commercial grade cleaning system will

clean your griddle in a matter of minutes. To order, contact your local

Viking dealer or order on the Viking website at vikingrange.com.

• The double griddle has two thermostat control knobs which control

separate burners located beneath the griddle.

• When the griddle has reached the desired

temperature, the power “ON” indicator light

will turn off, indicating the griddle is

Griddle Assembly

Grease trough

preheated to the selected temperature.

• Use liquid cooking oil or butter for eggs,

pancakes, French toast, fish and sandwiches to

prevent sticking.

• Routinely scrape loose food particles with a

metal spatula during cooking to make the

cleanup easier and to avoid the particles mixing with the food.

• To turn the griddle off, turn the thermostat knob clockwise to the

“OFF” position.

Griddle Cooking Chart

Griddle

Food

Temp (°F)

250-300

300-325

375-400

400

Temp (°C)

121-149

149-163

191-205

205

Eggs

Bacon

Pancakes

French Toast

Fish Fillets

Hamburger

Steaks

• ALWAYS turn to the“OFF” position when not in use and lower the

heat between cooking loads.

300

149

350

177

350

177

Operation

Char-Grill (on applicable models)

Char-Grill Cooking Tips (cont.)

The optional 18,000 BTU char-grill is equipped with a single piece,

heavy-duty porcelainized cast-iron grill grate for easy movement of

grilling items. Beneath the grill grate is a slotted porcelainized flavor-

generator plate which is designed to catch drippings and circulate a

smoke flavor back into the food. Beneath the flavor-generator plate is

a two-piece drip pan which catches any drippings that might pass

beyond the flavor-generator plate. This unique grilling system is

designed to provide outdoor quality grilling indoors.

• Turn the meat over only once. Juices are lost when steaks, chops or

hamburgers are turned several times. The best time to turn the meat

is after the juices have begun to bubble to the surface.

• To test for doneness, make a small slash in the center of the meat,

not the edge. This will prevent loss of juices.

• Occasionally there may be flare-ups or flames above the grill due to

drops of fat falling on the flavor-generator plates. It is normal to

have some flare-up during grilling. Use a long handled spatula to

move food to another area until the flames subside.

Char-Grill Assembly

Before using the char-grill, you will need to follow these steps to

properly assemble the char-grill.

• For ease of cleaning, leave the char-grill on for 10 minutes when

finished grilling. This will help make cleanup easier once the char-

grill has cooled down.

• Remove the two flavor-generator plates and grill grate from the

cardboard packaging.

Char-Grill Disassembly for Cleaning

Follow these steps to disassemble the char-grill for cleaning. Make sure

the char-grill is completely cool before attempting to disassemble for

cleaning.

• Remove the char-grill grate.

• Remove the flavor-generator plates.

• Position the flavor-generator plates so that the tab on each plate is

inserted in the right, rear hole and left, front hole on the drip pans.

(See Char-Grill Assembly section on following pages.)

• After the flavor-generator plates are properly located, place the grill

grate on top of the flavor-generator plates. After this, the char-grill is

assembled and ready to use.

• Remove the drip pan. Note that the drip pan is a two-piece drip

pan.

Char-Grill Operation

• Located beneath the burner is the drip tray. Under normal grilling

circumstances very little if any grease will accumulate in the drip tray.

If any grease has accumulated in the drip tray, simply wipe out with a

paper towel or damp cloth.

• Turn the overhead ventilation on prior to turning the grill on.

• Turn the grill knob counterclockwise to “HI”.

• Always preheat the grill for 5-10 minutes before placing food on the

grill grate.

• Place food items on the grill, cook as desired.

• To turn the grill off, turn the grill knob clockwise to the “OFF”

position.

Char-Grill Assembly

Grill

Char-Grill Cooking Tips

• When grilling chicken, roasts, well-done steaks or chops and thick

pieces of meat, sear on “HI”. Then, reduce the heat setting to

prevent excessive flare-up. This will allow the food to cook through

without burning the outside.

Flavor-

generator

plates

Two-piece

drip pan

• After steaks, chops, or hamburgers have been allowed to sear for

approximately one minute, you may slide a spatula under the meat

and turn it approximately 90 degrees so that a waffle pattern will be

seared onto the food.

• Use a metal spatula instead of tongs or a fork to turn the meat. A

spatula will not puncture the meat allowing juices to escape.

Burner

Drip tray

Operation

Grill Cooking Chart

Char-Grill Assembly (cont.)

Suggested Special instructions

Flame cooking

size time (min)

Weight or

thickness

and tips

Food

BEEF

Hamburger

1/2”(1.3 cm) – Med

3/4” (1.9 cm)

8 – 15

Grill, turning once

when juices rise

to the surface.

We recommend

that ground

chuck be used for

hamburgers, as

it will give you a

juicer hamburger

than ground

round. DO NOT

leave hamburgers

unattended since a

flare-up could

occur quickly.

Char-Grill Cleanup & Care

• Char-grill grates:

STEAKS

o May be cleaned immediately after cooking is complete and before

turning off the flame. Before cleaning the grill, turn the fame down

to a lower setting such as “MED” or “LOW”. Use a soft bristle

brush to scrub the grill grate. Dip the brush frequently into a bowl

of water. Steam is created as the water contacts the hot grate. The

steam assists the cleaning process by softening the food particles.

o For a thorough cleaning of the grill grate, use grill cleaner

according to manufacturer’s directions and then soak 15-20

minutes in a hot water and mild detergent solution. After soaking,

scrub with a blue Scotch-Brite™ pad. DO NOT use a steel wool

pad or abrasive cleaner, for risk of damaging the porcelain finish.

Dry thoroughly.

Rib, Club, Porterhouse, T-Bone, Sirloin

Rare 1” (2.5 cm) High

(140°F/60°C) 1-1/2” (3.8 cm) High

Medium 1” (2.5 cm) Med

(160°F/71°C) 1-1/2” (3.8 cm) High

Well-done 1” (2.5 cm) Med

(170°F/77°C) 1-1/2” (3.8 cm) High

Remove excess fat

from edge. Slash

remaining fat at 2”

(5.1 cm) intervals to

keep edges from

curling. Grill,

8 – 12

11 – 16

12 – 20

16 – 25

20 – 30

25 – 35

turning once.

5 lbs. (2.3 kg)

High

30 – 40

Remove surface fat

and connective

tissue. Fold over

thin end to form

uniformly thick

Tenderloin

• Flavor-generator-plates and drip pan:

o Scrape off all burned on debris. The flavor-generator plates and

drip pan are dishwasher safe. If you choose to not wash these

components in the dishwasher, then simply soak for 15-20 minutes

in a hot water and mild detergent solution. After soaking, scrub

with a blue Scotch-Brite™ pad.

piece. Bind with

string. Grill, turning

to brown evenly.

Brush often with

melted butter,

margarine or oil.

Cook until rare.

Operation

Cooking Substitutes Charts

Grill Cooking Chart

In many cases, a recipe requires an ingredient which is not readily

available or calls for a unit of measure that is not easily recognized.

The following charts have been provided as useful guides in

these situations.

Suggested Special instructions

Weight or

Flame cooking

size time (min)

and tips

Food

thickness

PORK

Chops

Ingredient Substitutes

1/2”(1.3 cm)

1” (2.5 cm)

Med

20 – 40

35 – 60

Remove excess fat

from edge. Slash

remaining at 2”

(5.1 cm) intervals to

keep edges.

Recipe calls for:

Substitute with:

1 tbsp. cornstarch

2 tbsp. flour (thickening)

1 whole egg

2 egg yolks plus 1 tbsp. water

1 c. skim milk plus 2 tbsp. margarine or

1/2 c. evaporated milk plus 1/2 c. water

1 c. whole milk

Ribs

Med

45 – 60

Grill, turning

occasionally. During

the last few minutes,

brush barbecue

sauce, turning

1 oz. unsweetened chocolate 3 tbsp. cocoa powder plus 1 tbsp. margarine

1 tbsp. baking powder

1/2 tsp. cream of tartar plus 1/4 tsp. baking

soda

several times.

1/2 c. butter

7 tbsp. margarine or shortening

Ham steaks

(fully cooked)

1/2” (1.3 cm)

High

Med

12 – 15

5 – 10

Remove excess fat

from edge. Slash

remaining fat at

two-inch intervals.

Grill, turning once.

1 c. dairy sour cream

1 tbsp. lemon juice plus 1 c. evaporated milk

Canned Food Sizes

Can Size

8 oz.

Contents

Can Size

No. 303

No. 2

Contents

2 c.

1 c.

Hot dogs

Slit skin before

cooking. Grill,

turning once.

Picnic

1-3/4 c.

2 c.

2-1/2 c.

4 c.

No. 300

No. 1 tall

No. 3

No. 10

12 c.

POULTRY

Chicken

2 (0.9 kg) –

3 lbs. (1.4 kg)

High

Med

60 – 90

40 – 60

Place skin side up.

Grill, turn, and

brush frequently

with melted butter,

margarine, oil, or

marinade.

Kitchen Equivalent and Metrics

Broiler/Fryer

– Halves or

Quarters

Measure

1 tbsp.

2 tbsp.

1 jig.

Equivalent

3 tsp

Metric*

15 mL

30 mL

45 mL

60 mL

1 oz

1-1/2 oz

4 tbsp.

FISH AND SEAFOOD

Steaks 3/4” (1.9 cm) – Med to

Halibut

Salmon

Swordfish

1/4 c.

1/3 c.

1/2 c.

1 c.

5 tbsp. plus 1 tsp.

8 tbsp.

80 mL

125 mL

250 mL

30 g

8 – 15

Grill, turning once,

brush with melted

butter, margarine,

or oil to keep fish

moist.

1” (2.5 cm) High

16 tbsp.

2 c.

1 pt.

1 lb.

16 oz

454 g

Whole

Catfish

Trout

4 oz (113 g) – Med to 12 – 20

8 oz (227 g)

2.21 lb.

35.3 oz

1 kg

High

*Note: Rounded for easier measuring.

Cleaning and Maintenance

Any piece of equipment works better and lasts longer when

maintained properly and kept clean. Cooking equipment is no

exception. Your rangetop must be kept clean and maintained properly.

Before cleaning, make sure all controls are in the “OFF” position.

Disconnect power if you are going to clean thoroughly with water.

Burner Head

If ports on burner head are clogged, clean with a straight pin.

DO NOT enlarge or distort the ports. DO NOT use a toothpick to

clean the ports. When replacing burner head, carefully align the 2 tabs

underneath the burner head with the outside edge of burner base.

Make sure the tabs are not aligned with the igniter and the burner cap

is level.

Surface Burners

Note: For stubborn stains, use a non abrasive cleanser such as Bon

Ami™ and a soft brush or soft Scotch Brite™ pad.

Burner

grate

Cleaning Tip: For difficult to clean burner caps and heads, place parts

in a zip seal bag with ammonia.

Burner

cap

Igniter

Burner Base

Burner

The base should be wiped regularly with hot soapy water at the end of

each cooling period. DO NOT use steel wool, abrasive cloths, cleanser,

or powders. To remove encrusted materials, soak the area with a hot

towel to loosen the material, then use a wooden nylon spatula.

DO NOT use a metal knife, spatula, or any other metal tool to scrape

the aluminum base.

head

Burner

base*

*Note: When replacing burner head, arrow must be pointing towards

back of rangetop.

• Wipe up any spills which remain on the sealed top surface.

• Replace burner cap, burner head, and grates after drying thoroughly.

Wipe up spillovers as soon as possible after they occur and before

they get a chance to burn in and cook solid. In the event of a

spill-over, follow these steps:

• Allow the burner and grate to cool to a safe temperature level.

• Lift off the burner grate. Wash in warm soapy water.

• Remove the burner cap and burner head and clean.

Control Panel

DO NOT use any cleaners containing ammonia or abrasives. They

could remove the graphics from the control panel. Use hot, soapy

water and a soft clean cloth.

Control Knobs

MAKE SURE ALL THE CONTROL KNOBS POINT TO THE OFF

POSITION BEFORE REMOVING. Pull the knobs straight off. Wash in

detergent and warm water. Dry completely and replace by pushing

firmly onto stem. DO NOT use any cleaners containing ammonia or

abrasives. They could remove the graphics from the knob.

Burner Caps

The surface burner caps should be routinely removed and cleaned.

ALWAYS clean the burner caps after a spill-over. Keeping the burner

caps clean will prevent improper ignition and uneven flames. To clean,

pull burner cap straight up from the burner base. Wipe off surface

burner caps with warm, soapy water and a soft cloth after each use.

Use a non-abrasive cleanser such as Bon Ami™ and a soft brush or soft

Scotch Brite™ pad for cooked-on foods. Dry thoroughly after cleaning.

For best cleaning and to avoid possible rusting, DO NOT clean in

dishwasher or self-cleaning oven.

Troubleshooting

Cleaning and Maintenance

Stainless Steel Parts

Problem

Possible Cause and/or Remedy

Some stainless steel parts may have a protective wrap, which must be

peeled off. All stainless steel body parts should be wiped regularly with

hot, soapy water at the end of each cooling period and with liquid

cleaner designed for this material when soapy water will not do the job.

If build-up occurs, DO NOT use steel wool, or abrasive cloths, cleaners,

or powders. If it is necessary to scrape stainless steel surface to remove

encrusted material, soak area with hot, wet towels to loosen the material,

then use a wooden or nylon spatula or scraper. DO NOT use a metal

knife, spatula, or any other metal tool to scrape stainless steel surfaces.

Scratches are almost impossible to remove. DO NOT permit citrus or

tomato juice to remain on stainless steel surface, as citric acid will

permanently discolor stainless steel. Wipe up any spills immediately.

Igniters will not work.

Circuit is tripped.

Fuse is blown.

Rangetop is not connected to power.

Gas supply valve is in “OFF” position.

Igniters sparking but no

flame ignition.

Gas supply is interrupted.

Igniters sparking

continuously after flame

ignition.

Power supply is not grounded.

Power supply polarity is reversed.

Igniters are wet or dirty.

Burner ports are clogged.

Power Failure

Burner ignites but flame is

large, distorted, or yellow.

If power failure occurs, the electric igniters will not work. No attempt

should be made to operate appliance during a power failure. Make

sure surface controls are in “OFF” position.

Unit is being operated on wrong type of gas.

Air shutters not properly adjusted.

WARNING

BURN OR ELECTRICAL SHOCK HAZARD

Make sure all controls are “OFF” and rangetop is

COOL before cleaning. Failure to do so can result

in burns or electrical shock.

WARNING

POWER FAILURE WARNING

Due to safety considerations and the possibility of personal injury in

attempting to light and extinguish the burner, the grill should, not under

any circumstances, be used during a power failure. The grill burner

control should always remain in the “OFF” position during a power failure.

Warranty

Service Information

PROFESSIONAL SERIES

If service is required, call your dealer or authorized service agency.

The name of the authorized service agency can be obtained from the

dealer or distributor in your area.

CUSTOM BUILT-IN GAS RANGETOPS WARRANTY

THREE YEAR FULL WARRANTY

Gas rangetops and all of their component parts, except as detailed below*†, are warranted to be free

from defective materials or workmanship in normal residential use for a period of three (3) years from the

date of original retail purchase or closing date for new construction, whichever period is longer. Viking Range

Corporation, warrantor, agrees to repair or replace, at its option, any part which fails or is found to be

defective during the warranty period.

Have the following information readily available.

• Model number

*FULL NINETY (90) DAY COSMETIC WARRANTY: Product is warranted to be free from

cosmetic defects in materials or workmanship (such as scratches on stainless steel,

paint/porcelain blemishes, etc.) for a period of ninety (90) days from the date of original retail

purchase or closing date for new construction, whichever period is longer. Any defects must be

reported to the selling dealer within ninety (90) days from date of original retail purchase.

Viking Range Corporation uses high quality processes and materials available to produce all

color finishes. However, slight color variation may be noticed because of the inherent

differences in painted parts and porcelain parts as well as differences in kitchen lighting,

product locations, and other factors. Therefore, this warranty does not apply to color variation

attributable to such factors.

• Serial number

• Date purchased

• Name of dealer from whom purchased

Clearly describe the problem that you are having. If you are unable to

obtain the name of an authorized service agency, or if you continue

to have service problems, contact Viking Range Corporation at

1-888-VIKING1 (845-4641), or write to:

†FULL NINETY (90) DAY WARRANTY IN "RESIDENTIAL PLUS" APPLICATIONS: This full

warranty applies to applications where use of the product extends beyond normal residential

use, but the warranty period for products used in such applications is ninety (90) days.

Examples of applications covered by this warranty are bed and breakfasts, fire stations, private

clubs, churches, yachts, etc. Under this "Residential Plus" warranty, the product, its components

and accessories are warranted to be free from defective material or workmanship for a period

of ninety (90) days from the date of original retail purchase. This warranty excludes use of the

product in all commercial locations such as restaurants, food service locations and institutional

food service locations.

VIKING RANGE CORPORATION

PREFERRED SERVICE

1803 Hwy 82W

Greenwood, Mississippi 38930 USA

FIVE YEAR LIMITED WARRANTY ON BURNERS

Any surface burner, griddle burner, or grill burner which fails due to defective materials or workmanship

(excluding cosmetic failures) in normal household use during the fourth through fifth year from the date of

original retail purchase will be repaired or replaced, free of charge for the part itself, with the owner

paying all other costs, including labor. This does not include ignition systems, burner bases, etc.

Record the information indicated below. You will need

it if service is ever required. The model and serial

number for your rangetop can be found by lifting up

the front of the unit and looking underneath on the

base.

TERMS AND CONDITIONS

This warranty extends to the original purchaser of the product warranted hereunder and to each transferee

owner of the product during the term of the warranty and applies to products purchased and located in

the United States and Canada. Products must be purchased in the country where service is requested. If

the product or one of its component parts contains a defect or malfunction during the full warranty period

after a reasonable number of attempts by the warrantor to remedy the defect or malfunction, the owner is

entitled to either a refund or replacement of the product or its component part or parts. Replacement of a

component part includes its free installation, except as specified under the limited warranty. Under the

terms of this warranty, service must be performed by a factory authorized Viking Range Corporation

service agent or representative. Service will be provided during normal business hours, and labor

performed at overtime or premium rates shall not be covered by this warranty.

Owner shall be responsible for proper installation, providing reasonable and necessary maintenance,

providing proof of purchase upon request, and making the appliance reasonably accessible for service.

The return of the Owner Registration Card is not a condition of warranty coverage. You should, however,

return the Owner Registration Card so that Viking Range Corporation can contact you should any question

of safety arise which could affect you.

Model no._____________________ Serial no. ________________________

Date of purchase _______________ Date installed ___________________

Dealer’s name __________________________________________________

Address ________________________________________________________

_______________________________________________________________

This warranty gives you specific legal rights, and you may also have other rights which may vary from

jurisdiction to jurisdiction.

WHAT IS NOT COVERED BY THIS WARRANTY: This warranty shall not apply to damage resulting from

abuse, failure to provide reasonable and necessary maintenance, accident, delivery, negligence, natural

disaster, loss of electrical power to the product for any reason, alteration, outdoor use, improper installation,

improper operation, or repair or service of the product by anyone other than an authorized Viking Range

Corporation service agency or representative. This warranty does not apply to commercial usage.

If service requires installation of parts, use only authorized parts to insure

protection under the warranty.

Keep this manual for future reference.

Warranty (cont.)

Notes

LIMITATION OF REMEDIES AND DURATION OF IMPLIED WARRANTY

OWNER’S SOLE AND EXCLUSIVE REMEDY FOR A CLAIM OF ANY KIND WITH RESPECT TO THIS

PRODUCT SHALL BE THE REMEDIES SET FORTH ABOVE.VIKING IS NOT RESPONSIBLE FOR

CONSEQUENTIAL OR INCIDENTAL DAMAGE, INCLUDING BUT NOT LIMITED TO FOOD OR

MEDICINE LOSS, DUE TO PRODUCT FAILURE, WHETHER ARISING OUT OF BREACH OF

WARRANTY, BREACH OF CONTRACT OR OTHERWISE. Some jurisdictions do not allow the exclusion or

limitation of incidental or consequential damages, so the above limitation or exclusions may not apply to

you. ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE

APPLICABLE TO THIS PRODUCT ARE LIMITED IN DURATION TO THE PERIOD OF COVERAGE OF

THE APPLICABLE EXPRESS WRITTEN LIMITED WARRANTIES SET FORTH ABOVE. Some states do not

allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you.

_____________________________________________________________________________________________________

WARRANTY SERVICE

To obtain warranty service, contact an authorized Viking Range Corporation service agent, or Viking Range

Corporation, 111 Front Street, Greenwood, Mississippi 38930, (888) 845-4641. Provide model and serial

number and date of original purchase or closing date for a new construction. For the name of your nearest

authorized Viking Range Corporation service agency, call Viking Range Corporation.

IMPORTANT: Retain proof of original purchase to establish warranty period.

Specifications subject to change without notice.

Texas Instruments Laptop TM5000 Series User Manual
Tokina Camera Accessories TC0614AI User Manual
TP Link Marine Battery TL SM311 User Manual
Tripp Lite Network Cables A200 012 User Manual
Tripp Lite Network Cables P580 010 User Manual
Tyco Network Card Escort5580TC User Manual
Uniden Cordless Telephone DSS 2475 User Manual
Vornado Fan CR1 0228 55 User Manual
Weber Gas Grill 2000 LX Series User Manual
Weed Eater Blower 545137215 User Manual